1985 BMW 5-Series 524TD
Sale price: $US $5,875.00 make an offer
Technical specifications, photos and description:
|Type:||4 door sedan|
|Engine:||2.4L 6 cylinder Turbo Diesel|
|Got questions?||Ask here!|
Do you like this car?
1985 BMW 5-Series 524TD for sale
Ultra rare BMW for you diesel lovers out there. Superb condition. e28 5-series with a 2. 4L 6cyl TurboDiesel engine. New interior. pristine dash. and mechanical injection pump conversion are just some of the highlights. I've owned this car for 3 years and it was very solid to start with. which is why I could not resist buying it.
Highlights: Official Canadian spec 524TD. This car has spent its life in virtually snow-free lower mainland British Columbia. US and Canadian cars were identical except for some decals and the km/h only speedo (Note: a US spec 524TD IP cluster in MPH is included with the sale). Only about 150 of these were imported into Canada. roughly 3000 into the US. Of special note is the exemplary. as new. condition of the dash. Finding any e28 without a cracked dash these days is near impossible.
Work performed since I purchased it
Transmission mountsRear sub frame bushingsGlow PlugsGlow plug control moduleEngine bay cleaned and detailed
Interior:Seats reupholsteredDoor panelsRear parcel shelfSI board bypassOriginal BMW radio/cassette player with security codeFloor mat setExterior:
Lockstrips surrounding windshield and rear glassDoor weatherstripsSunroof sealsPower antennaExcellent Goodyear tiresBase/clear respray preformed with every single piece of trim removed – I mean everything!In General:
143. 00 miles / 230. 00 kmBC Collector plate approved (validation of excellent condition and factory stock requirements)
Superb presentation and condition
OF SPECIAL NOTE IS THE MECHANICAL INJECTION PUMP CONVERSION
All 524TDs imported into the US and Canada had a troublesome ECU controlled injection pump. Yes. the injection timing on the 524TD was controlled by a computer module – Argh! The ECU interference rendered these pumps tuning unfriendly and unreliable. The computer would interfere with timing or go into default “limp mode” if any of the sensors were either defective or timing signals were off. not to mention the annoying check engine “Injection” light. What's worst. these ECU system components are no longer available. Be aware of this Achilles heal if you are looking at other 524TDs! Very unfortunate. because this Bosch pump is virtually identical to the VE VW/Audi/Volvo pumps of the era and even the 1st gen Dodge Cummins pump.
The Cat's Meow: during the pump rebuild. it was converted over to a traditional mechanical timing system - as it should have been in the first place. IMHO! Brand new electro-mechanical KSB components were installed and the internal pressure of the pump calibrated accordingly for proper timing advance. When engine is cold. below about 27C/80F. a temp sensor activates the KSB to advance timing for a few minutes. These engines were also used in the Lincoln Mark VII's and Continentals with factory mechanical fuel injection. so essentially. this conversion replicates that.
The pump is now 100% mechanically controlled and works as traditional. reliable. Bosch VE units of the era. It can now be adjusted for optimum fuel efficiency and power. If desired. you can now also tweak and perform any and all adjustments that are well documented by the VW and Cummins crowd (and Euro 524TDs) as per your personal preference.
More importantly. this also means. that if ever needed. any diesel shop can diagnosis and repair it as easily as other traditional old-school diesels. Just try taking a regular ECU controlled 524TD for repair and even a BMW dealer does not want to touch it!
NOTE: Even though the pump was converted to mechanical operation. all the sensors and wiring were left completely intact to preserve factory stock appearance. Nothing was torn out – though. if desired. these redundant components can be removed for a cleaner look. All the sensors. ECU. etc. . are still in the car and functional (though. obviously the ECU connection to the pump is now redundant). It could be converted back to ECU control (though I can't imagine why anyone ever would!) and if that's the route you want to go. I will explain what needs to be done.
This car has NEVER had biodiesel or SVO run in it. However. with the now traditional mechanical injection pump. such a conversion is now a practical option as folks have been doing for years.
I had intended to do a Euro bumper conversion at some point. so even the bodywork under the US style bumpers is superb and ready.
This is a wonderful car for a BMW and/or diesel enthusiast owner who truly understands and appreciates the scope of the mechanical pump conversion. crack free dash. new interior. its rarity. appreciating value and much more.
There are a few minor. laughable really. issues for a vehicle of this age: The a/c was blowing somewhat cold when I bought it. but now likely needs a recharge. I just didn't get around to fixing the cruise control because it's something I never use. When the weatherstripping was replaced last month with an almost new-like set. the doors now need a wee firmer push than before to close. however. this will resolve itself once the summer heat softens and sets in the newer rubber.
Extras included: A spare US spec 524TD instrument cluster that reads in MPH. A brand new. unused. custom made set of floor mats. Some very useful documentation and manuals I've collected over the years on a USB for reference.
Shipping is the responsibly of the buyer. but I'll do my best to assist. Car is located 15 minutes from the US/Canada border beside Blaine. WA on the Canadian side. Can bring the car to or across the border. if desired. when all paperwork is in order. Being over 25 years old. it can be imported into the USA very easily without any issues.
Now to get the obligatory legal stuff out of the way. I must point out: I am not a car dealer. this is my personal vehicle. Sale is final. as is. with no warranties expressed or implied. No one has a crystal ball and if any issues develop or be discovered after the sale. buyer is 100% responsible. It is a 32 year old vehicle after all! I will happily answer any questions via email or phone (Harry: 778-835-8686) and have done my best to express the condition with over 100 photos and description. Buyer is 100% responsible for inspecting the vehicle prior to bidding. By placing a bid you acknowledge that you have read and understand and agree to the terms of this listing.
Keep in mind. this car was owned by an enthusiast and it deserves to be enjoyed by an enthusiast. I am only selling it because of a massive lifestyle shift in circumstances that has occurred; hence a very low reserve. I had intended to keep it forever. The amount of work done and the attention to detail reflect that.
To paraphrase the BMW spin department. this is the Ultimate Diesel Driving Machine . . . (of the 80s!)
To view photos. just click a photo thumbnail below to bring up the slideshow and you'll be able to scroll through them all easily.
Alternative Direct View Link 1:
Alternative Download All and View Link 2:
Also published at eBay.com
Want to buy this car?
Comments and questions to the seller:
Other classic Audi cars offered via internet auctions:
price: $29,995.001980 Jeep Wrangler CJ7
price: £7,495.002010 (60 PLATE) AUDI A4 "TECHNIK" 2.0 TDi S-LINE, TURBO DIESEL, HUGE TOP SPEC
price: $14,990.001963 Chevrolet C-10 Custom Pickup RestoMod
price: $US $24,600.001930 Ford Model A Tudor
|1965 Chevrolet C-10 --||21||$14,995.00|
|1989 Porsche 944||4||$14,995.00|
|1986 Audi 5000 Quattro||9||$US $2,000.00|
|1987 Audi Coupe||21||$3,000.00|
|1978 Chevrolet El Camino||12||$US $4,000.00|
|1986 Mercedes-Benz E-Class||9||$7,750.00|
|1989 Mercedes-Benz SL-Class||21||$14,977.00|
|1965 Chevrolet C-10 --||21||$14,500.00|
|1980 Pontiac Trans Am Bandit Edition 6.6L||21||$27,995.00|
|1979 Volkswagen Specialty 4 Wheel Drive Iltis||10||$US $6,500.00|
|1987 Audi Coupe||21||$3,500.00|
|1987 Porsche 924||21||$US $6,000.00|
|1929 Ford Model A||21||$39,990.00|
|1989 Porsche 944||4||$14,995.00|
|Audi 5000S/ 5000CS Manual 1984-1988||8||$89.99|
|1984 Porsche 944||21||$US $6,601.00|
|1978 Chevrolet El Camino||12||$US $3,900.00|
|1979 Volkswagen Thing||10||$US $5,000.00|
|1969 Ford Mustang Grande Hardtop||21||$17,995.00|
|1965 Chevrolet C-10 --||21||$16,995.00|